CONTROL MODULE PIN OUT INFORMATION
AIRBAG / SRS SINGLE POINT SENSOR
v Pin
Description
Active
0
CAS1-I
LH SEAT BELT WETENSIONER POWER SUPPLY
B+
0
C&l-2
LH SEAT BELT PRETENSIONER GROUND SUPPLY
GROUND
0 CAS,-3
RH SEAT BELT PRETENslONER POWER SUPPLY
BT
0 CAS,-4
RH SEAT BELT PRETENslONER GROUND SUPPLY
GROUND
I CA61-5
IGNITION SUPPLY VOLTAGE
B+
I CA6M
GROUND SUPPLY
GROUND
0 CAS,-7
INSTRUMENT PACK’SRS’ MIL
GROUND (NO FAULT,
D
CA61-9
DIAGNOSTIC OUTPUT SERIAL OUTPUT
ENCODED COMMUNICATION
0
CAG1-10
STEERING WHEEL AIR&&G POWER SUPPLY
B+
0 CAS,-ll
STEERING WHEEL AIRBAG GROUND SUPPLY
GROUND
0
CA61-13
PASSENGER FASCIA AIRBAG POWER SUPPLY
ST
0 CA61-14
PASSENGER FASCIA AlRBAG GROUND SUPPLY
GROUND
0 CAB,-16
DRIVER SiDE AIRBAG POWER SUPPLY
B+
0
CM-17
DRIVER SDE AIRBAG GROUND SUPPLY
GROUND
0
CASI-18
PASSENGER SIDE AIRBAG POWER SUPPLY
B+
0 CA61~19
PASSENGER SIDE AIRBAG GROUND SUPPLY
GROUND
1 CA61-20
LH SIDE hIPACT SENSOR GROUND SUPPLY
GROUND
I CASI-21
RH SIDE IMPACT SENSOR GROUND SUPPLY
GROVND
1 CA61~22
LH SIDE IMPACT SENSOR STATUS
GROUND (SHORTED)
1 CM-23
RH SIDE IMPACT SENSOR STATUS
GROVND ,SHORTEDi
I C.461~24
LH SIDE IMPACT SENSOR GROUND SUPPLY STATUS
GROUND ,NO FAULT)
I CA61-25
RH SIDE IMPACT SENSOR GROUND SUPPLY STATUS
GROUND (NO FAULT)
0
CM,-40
SW AUDiBLE BACKUP
ENCODED COMMUNICATIONS
Inactive
OPEN CIRCUIT
OPEN CIRCUIT
OPEN CIRCUIT
OPEN CIRCUIT
GROUND
GROUND
SC
OPEN CIRCUIT
OPEN ClRCUiT
OPEN ClRCUlT
OPEN CIRCUIT
OPEN CIRCUIT
OPEN CIRCUIT
OPEN CIRCUIT
OPEN CIRCUIT
B+
B+
SC
B+
GROUND
GROUND
COMPONENTS
Component
,uRBAG, SRS SINGLE POINT SENSOR
A,RBAG - DRIVER SIDE
AIRBAG - PASSENGER SIDE
SEAT BELT WETENSIONER - LH
SEAT BELT PRETENSIONER- RH
SlDE AIRBAG -DRIVER
SlDE AiRBAG - PASSENGER
S,DE lMPACT SENSOR LH
SlDE lMPACT SENSOR - RH
SPL,CE HEADER - CA225
Connector
I
Type
I
Color
CAM, %-WAY EL050 /YELLOW
SW, ,,3-w*Y EPC i BLACK
CA.81 , SWAY CARDEL, FORD, GREY
CA.62, Z-WAY FORD AIRBAG, YELLOW
CA&, 2.WAY FORD AlRBAG , YELLOW
SM,S-D,?-WPIYAMPHENOL,YELLOW
SM,5-P,2WAYAMPHENOL,YELLOW
CA,S, S-WAY MOLEX C-GRID, BLACK
CA**, B~WAIY MOLEX C-GRID, BLACK
CA225, ZO~WAY S”MlTOM0 SPLICE HEADER /
Location / Access
BELOW CENTER CONSOLE ASSEMBLY
CENTER OF STEERlNG WHEEL
PASSENGER AIR BAG
INSlDE LH ‘WC’ POST, ‘WC POST TRIM
iNSIDE RH ‘WC’ POST, ‘WC’ POST TRIM
DRIVER SEAT, SIDE
PASSENGER SEAT, SlDE
INSIDE ‘B/c’ POST, ‘B/C’ POST TRIM
INSIDE ‘WC POST,‘B,C’ POSTTRIM
JRAL
LH HEELBOARD, HEELBOARD COVER
HARNESS-TO-HARNESS CONNECTORS
Connector
Type / Color
Location
I
Access
CA66
3.WAY FORD, CARD, BLACK
BELOW SEAT
CA72
3.WAY FORD, CARD, BLPLCK
BELOW SEAT
FC5
54.WAY THROUGH PANEL CONNECTOR, BLACK
BELOW DR,“ER SiDE AIR VENT, COIN TRAY
SW,0
J-WAY EPC, BLACK
CENTER OF STEERING WHEEL
GROUNDS
Ground
Location / Type
CA48
EYELET (SINGLE) RH HEELBOARD POST GROUND SCREW MRBAG ONLY GROUND)
CONTROL MODULE PIN OUT INFORMATION (FOLD OUT PAGE)
The following symbols are used to represent values for Control Module Pin Out data:
I
Input
D Serial and encoded communications B+ Battery voltage KHz Frequency x 1000
0 output
C CAN (Network)
V Voltage (DC)
MS Milliseconds
SG Signal Ground
S SCP Network
Hz Frequency
MV Millivolts
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
ComPonents connected and fitted.
“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
REFER TO THE FRONT OF THE BOOK FOR ILLUSTRATIONS DETAILING THE LOCATION AND IDENTIFICATION OF COMPONENTS, RELAYS,
CONNECTORS, HARNESSES, GROUNDS, VEHICLE CONTROL MODULES AND CONTROL MODULE PINS.
DATE OF ISSUE: SEPTEMBER 1997
