CONTROL MODULE PIN OUT INFORMATION
AIR CONDITIONING CONTROL MODULE
D Pin
I cm-1
0 CC28-2
0 cc**-3
0 CC%4
0 K-28-5
0 CC%16
0 CC28~17
0 cc**-18
Description
COMPRESSOR CLUTCH STATUS
HEATER VALVE ACTl”E
RH BLOWER MOTOR RELAYACTlVE
LH / RH WlNDSHlELD HEATER RELAYS ACT,
DOOR MIRROR HEATER RELAY ACTIVATE
LH BLOWER MOTOR RELAYACTlVATE
HEATER PUMP RELAY ACTIVATE
HEATED BACKLIGHT RELAY ACTIVATE
Active
B+ iON1
B+
0”
0”
0”
B-
0”
0”
Inactive
0”
0”
B-
Es+
*+
0”
BL
B-
7 6 ” = LOW SPEED
0 83” = HIGH SPEED
13 ” = LOW SPEED
0” = HIGH SPEED
7.6 ” = LOW SPEED
083”=HlGHSPEED
1.3 v = LOW SPEED
0” = HIGH SPEED
B-
0”
COMPONENTS
Component
AIR CONDlTlONlNG COMPRESSOR CLUTCH
Connector / Type / Color
P,36! ,-WAY SUMITOMO 90 ATYPE, BLACK
Location / Access
ENGlNE COMPARTMENTiA,C COMPRESSOR
AIR CONDlTlONlNG CONTROL MODULE
CC28 /26-W*” MULTILOCK 47, GREY
CC29,16-WAY M”LTlLOCK 47, GREY
CCX, 12.WAY MULTlLOCK 471 GREY
cc31 ,22-W*” MULTILOCK 471 GREY
RH SiDE OF TRANSMISSION TUNNEL! GLOVE BOX ASSEMBLY
AIR CONDlTlONlNG CONTROL PANEL
cc27: 12~WAY MULTlLOCK 040, BLUE
CENTER CONSOLE
BLOWER MOTOR - LH
CCBZ ,i~WAY SUMlTOMO 90 HYBRID/ GREEN
LH SIDE FASCIA GLOVE BOX
BLOWER MOTOR - RH
CC33 i 15WAY SUMITOMO 90 HYBRID, GREEN
RH SIDE FASCIA GLOVE BOX
OOOR MIRROR DRIVER
DD8 / 12.WAY MULTlLOCK 040: BLACK
DRIVER DOOR
DOOR MIRROR PASSENGER
PD8, IP-WAY MULTILOCK 040, SLACK
PASSENGER DOOR
ccm7
RH BLOWER SPEED FEEDBACK
0 cc*%8
RH BLOWER SPEED CONTROL DRIVE S,GNAL
I cc29-15
LH BLOWER SPEED FEEDBACK
0
029~16
LH BLOWER SPEED CONTROL DRIVE SIGNAL
0
cmo-1
*m CONDlTlONiNG ELECTRICAL LOAD SIGNA,
I cm-7
LOAD ,NHlBlT
0
cc31-9
COMPRESSOR CLUTCH ON REOUEST
I CC31~17
REFRIGERANT 4WAY PRESSURE SWTCH
ENGINE CONTROL MODULE
EMlO, **-WAY MULTILOCK 040 i GREY
ENGlNE COMPARTMENT: CONTROL MODULE ENCLOSURE
EM,, ! IS-WAY MULTILOCK 040, GREY
EM12 i22-WAY MULTILOCK 040! GREY
EM,3,34-WAY MVLTlLOCK 040, GREY
EMili 12.WAY MULTlLOCK 47,WHiTE
EM15,22-WAY M”LTILOCK47 OVHITE
FUSE BOX- ENGINE COMPARTMENT
LSS, ,O-WAY “.T A FUSE BOX, NATVRAL
LS6,10-WAY ” T A FUSE BOX, BLACK
LS7, 10.WAY ” LA FUSE BOX, GREEN
158 / 1%WAY ” T A FUSE BOX, BLUE
ST19, EYELET
ENGINE COMPARTMENT, LH FRONT
B+
0”
BL (OUT OF ACTIVE RANGE1
FUSE BOX TRUNK
BTlO, 10.WAY “.T.A FUSE BOX, NATURAL
TRUNK ELECTRICN CARRIER
BTll , IO-WAY “.T.A FUSE SOX, BLACK
8112,10-WAY “.TA FUSE BOX/GREEN
Ems, 10.WAY “.T A. FUSE BOX, BLUE
ST&t, EYELET
ENGINE CONTROL MODULE
n Pin
Description
0
EM,&2
AICCM LOAD lNHlB,T
I EM10-3
A/cm ELECTRICAL LOAD SIGNAL
I EM,&4
A,CCM COMPRESSOR CLUTCH REOUEST
I EM,Z-5
4 WAY REFRIGERANT SWlTCH HIGH PRESSURE
I EM12~6
4 WAY REFRIGERANT SWITCH HIGH PRESSURE
0
EM,?-10
AIR CONDITIONING COMPRESSOR RELAYACTlVATE
0
EM1315
SERlES ,LOW SPEED FAN ACTIVATE
0
EM13-16
PARALLEL IHIGH) SPEED FAN ACTIVATE
Active
GROUND
*+
BA
Inactive
B+
GROUND
GROUND
HEATED BACKLIGHT
CA21, LUCAR - LOCKING POSILOCK MKI
IC18, LUCAR
INSIDE ‘E’ POST, ‘E’ POST UPPER -iRIM
BEHlND LEFT HAND REAR OUARTER PANEL
HEATER PUMP
HEATERVALVE
RADIATOR FAN CONTROL RELAY MODULE
RADlATOR FAN - LH
RADlATOR FAN - RH
REFRIGERANT 4~WAY PRESSURE SWITCH
WlNDSHiELD HEATER - LH
WlNDSHiELD HEATER - RH
EKE, P-WAY ECONOSEAL 111 LC i BLACK
EM40, P~WAY ECONOSEAL 111 LC, WHiTE
LS31 ,*-WAY TRW, BLACK
WI 1 Z~WAY REINSHAGEN, BLACK
CF2, PNAY REINSHAGEN, BLACK
LSZG, S-WAY ECONOSEAL 111 LC , BLACK
SH4, Z-WAY AMP SERIES 187C, GREY
SK, Z-WAY AMP SERIES 187C, GREY
ENGINE COMPARTMENT, LEFTHAND REAR
ENGINE COMPARTMENT, LEFT HAND REAR
ENGINE COMPARTMENT,ADJ*CENTTO LH CRUSHTUBE
ENGINE COMPARTMENT, BELOW LH FAN
ENGlNE COMPARTMENT, BELOW RH FAN
ENGINE COMPARTMENT,ADJACENTTO LH SIDE OF RADIATOR
CONNECTOR ADJACENT TO HOOD LATCH
CONNECTOR ADJACENT TO HOOD LATCH
GROUND @ 20 BAR ,290 PSli
GROUND @ 12 BAR ,174 PSli
GROUND
GROUND
GROUND
B+
Bt
B+
RELAYS
Relay
AIR CONDITIONING COMPRESSOR CLUTCH RELAY
BLOWER MOTOR RELAY - LH
BLOWER MOTOR RELAY - RH
DOOR MIRROR HEATER RELAY
HEATED BACKLlGHT RELAY (%?I
HEATER PUMP RELAY Wli
WINDSHIELD HEATER RELAY- LH
WINDSHIELD HEATER RELAY- RH
Case Color
BROWN
BLUE
BLUE
BLVE
BROWN
BROWN
BLACK
BLACK
Connector / Color
EMZS, BROWN
CA%, BLUE
C.458, BLUE
CA18, BLUE
BUS
BUS
SK, BLACK
SH3, BLACK
Location I Access
CONTROL MODULE ENCLOSURE RELAYS, ENGINE COMPARTMENT
RH HEELBOARD RELAYS, HEELBOARD COVER
RH HEELBOARD RELAYS, HEELBOARD COVER
RH HEELBOARD RELAYS, HEELBOARD COVER
RELAY%?.TRUNKFUSE BOX,TR”NK
RELAYit’?, ENGINE COMPARTMENT FUSE BOX, ENGINE COMPARTMENl
FRONT BULKHEAD RELAYS /ENGINE COMPARTMENT
FRONT BULKHEAD RELAYS /ENGINE COMPARTMENT
HARNESS-TO-HARNESS CONNECTORS
Connector
ST4
CA10
CA12
CA19
CNO
EM1
EM42
EM51
EM53
LS3
LS32
PI,
Type I Color
54.WAY THROUGH PANEL, BLACK
S-WAY MULTILOCK 070, YELLOW
8.WAY MULTILOCK 070, YELLOW
ZO-WAY MULTILOCK 070, YELLOW
2GWAY MULTILOCK 070 /YELLOW
,l~WAY AUGAT 1.6, BLACK
I-WAY YAZAKI , GREY
,Z-WAY AUGAT 1 6, GREY
PO-WAY MULTILOCK &W/WHITE
S&WAYTHRO”GH PANEL CONNECTOR, BLACK
4.WAY YAZAKI , GREY
57.WAY SUMITOMO TSOW, BLACK
Location I Access
BELOW PARCEL SHELFITRUNK, REAR BULKHEAD, RH SIDE
DRIVER ‘K POST, DOOR HARNESS GAITER
PASSENGER ‘K POST, DOOR HARNESS GAITER
LH ‘K POST CONNECTOR MOUNTING BRACKET, LOWER ‘K POST FINISHER
RH ‘N POST CONNECTOR MOUNTING BRACKET, LOWER ‘A’ POST FINISHER
ENGlNE COMPARTMENT,ADJACENTTO ASS PUMP
BULKHEAD/REAR OF ENGINE
ENGINE COMPARTMENT,ADJACENTTO ASS PUMP
PASSENGER ‘A’ POST, LOWER ‘K POST FINISHER
LH ‘N POST, LOWER ‘K POST FlNlSHER
FORWARD OF LH FRONTSUSPENSION ARM
ENGINE COMPARTMENTiBULKHEAD, REAR OF ENGINE
GROUNDS
Ground
CA30R
CA33R
ccx
EM8R
EMllL
EM18R
IC6
Location I Type
EYELET (PAIRI - LH ‘A’ POST GROUND SCREW
EYELET (PAIR) - RH ‘t’ POST GROUND SCREW
EYELET ,PA,R, - DR,“E SHAFT TUNNEL GROUND STUD - LH SIDE
EYELET iPAiR EMS LH GROUND STUD
EYELET iPAIR, - EMS BULKHEAD GROUND STUD
EYELET (PAIR) - EMS BULKHEAD GROUND ST”0
EYELET (SINGLE)-TRUNK, LH FORWARD GROUND STUD
The following symbols are used to represent values for Control Module Pin Out data:
I
Input
0 output
SG Signal Ground
D Serial and encoded communications
C CAN (Network)
S SCP Network
B+ Battery voltage
U Voltage (DC)
Hz Frequency
KHz Frequency x 1000
MS Milliseconds
MV Millivolts
LSIOL
EYELET (PAIR, - LH FORWARD GROUND STUD
LSlOR
EYELET ,PAIR) - LH FORWARD GROUND STUD
KalL EYELET (PAIR) - RH FORWARD GROUND STUD
CONTROL MODULE PIN OUT INFORMATION (FOLD OUT PAGE)
+
REFER TO THE FRONT OF THE BOOK FOR ILLUSTRATIONS DETAILING THE LOCATION AND IDENTIFICATION OF COMPONENTS, RELAYS,
CONNECTORS, HARNESSES, GROUNDS, VEHICLE CONTROL MODULES AND CONTROL MODULE PINS.
CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY.
NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all
components
connected and fitted. “Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.
